Toyota Supra JZA80
W58 manual transmission
Cover
Introduction
Identification information
General repair instructions
For vehicles with data link connector 2 (DLC2)
For vehicles equipped with SRS airbag
For vehicles equipped with a catalytic converter
If vehicle is equipped with mobile communication system
For using OBDII scan tool or toyota hand-held tester
For vehicles equipped with traction control (TRAC) system
Inspection and adjustment of joint angle during removal and installation of propeller shaft
How to troubleshoot ECU controlled systems
How to proceed with troubleshooting
Customer problem analysis
Symptom confirmation and diagnostic trouble code check
Symptom simulation
Diagnostic trouble code chart
Problem symptoms table
Circuit inspection
Connector connection and terminal inspection
Continuity check (open circuit check)
Resistance check (short circuit check)
Visual check and contact pressure check
Connector handling
Check open circuit
Check short circuit
Check and Replace ECU
Vehicle lift and support locations
Abbreviations used in this manual
Glossary of SAE and Toyota terms
Maintenance
Outside vehicle
Inside vehicle
Under hood
Engine
Brake
Chassis
Body
Preparation
Engine mechanical (2JZ-GE)
Engine mechanical (2JZ-GTE)
Turbocharging
Emission control (2JZ-GE)
Emission control (2JZ-GTE)
SFI (2JZ-GE)
SFI (2JZ-GTE)
Cooling
Lubrication
Ignition system (2JZ-GE)
Ignition system (2JZ-GTE)
Starting system
Charging system
Clutch
W58 manual transmission
V160 manual transmission
A340E 2JZ-GE automatic transmission
A340E 2JZ-GTE automatic transmission
Propeller shaft
Suspension and axle
Brake system
Steering
Supplemental restraint system
Body electrical system
Body
Air conditioning system
Service specifications
Standard bolt
Maintenance torque specification
Engine mechanical (2JZ-GE)
Diagnostics
2JZ-GE engine
Pre-check. 2JZ-GE engine
2JZ-GE engine diagnostic trouble code chart
Parts location 2JZ-GE engine
Terminals of ECM 2JZ-GE engine
Problem symptoms table 2JZ-GE engine
Circuit inspection 2JZ-GE engine
2JZ-GTE engine troubleshooting
2JZ-GE Engine
CO/HC
Compression
Valve clearance
Ignition timing
Idle speed
Timing belt components
Timing belt removal
Timing belt inspection
Timing belt installation
Cylinder head components
Cylinder head removal
Cylinder head disassembly
Cylinder head inspection
Cylinder head replacement
Cylinder head reassembly
Cylinder head installation
Engine unit components
Engine unit removal
Engine unit installation
Cylinder block components
Cylinder block disassembly
Cylinder block inspection
Cylinder block replacement
Cylinder block reassembly
Exhaust system components
2JZ-GTE Engine
CO/HC
Compression
Valve clearance
Ignition timing
Idle speed
Timing belt components
Timing belt removal
Timing belt inspection
Timing belt installation
Cylinder head components
Cylinder head removal
Cylinder head disassembly
Cylinder head inspection
Cylinder head replacement
Cylinder head reassembly
Cylinder head installation
Engine unit components
Engine unit removal
Engine unit installation
Cylinder block components
Cylinder block disassembly
Cylinder block inspection
Cylinder block replacement
Cylinder block reassembly
Exhaust system components
2JZ-GTE Turbocharging
Turbocharger system 2JZ-GTE
2JZ-GE Emission control
Emission control systems 2JZ-GE
2JZ-GTE Emission control
Emission control systems 2JZ-GTE
2JZ-GE SFI
SFI system 2JZ-GE
2JZ-GTE SFI
SFI system 2JZ-GTE
Cooling
Cooling system
Lubrication
Oil and filter inspection
Oil and filter replacement
Oil pump components
Oil pump removal
Oil pump disassembly
Oil pump inspection
Oil pump installation
Oil cooler components 2JZ-GTE
Oil cooler removal 2JZ-GTE
Oil cooler inspection 2JZ-GTE
Oil cooler installation 2JZ-GTE
Oil nozzle 2JZ-GTE
Ignition system 2JZ-GE
2JZ-GE
Ignition system 2JZ-GTE
2JZ-GTE
Starting system
Starter
Starter relay
Service specifications
Charging system
On-vehicle inspection
Generator
Service specifications
Clutch
Troubleshooting
Clutch pedal
Clutch master cylinder
Clutch release cylinder
Clutch unit
Service specifications
W58 manual transmission
Operation
Troubleshooting
Assembly removal and installation
Component parts removal
Input shaft
Output shaft
Counter gear and reverse idler gear
Front bearing retainer
Extension housing
Сontrol shift lever retainer
Service specifications
V160 manual transmission
Troubleshooting
Assembly removal and installation
Oil seals
Service specifications
A340E 2JZ-GE automatic transmission
Operation
Precaution
On-vehicle repair
Assembly removal and installation
Shift lock system
Troubleshooting
Service specifications
A340E 2JZ-GTE automatic transmission
Operation
Precaution
On-vehicle repair
Assembly removal and installation
Shift lock system
Troubleshooting
Service specifications
Propeller shaft
Precaution
Propeller shaft
Service specifications
Suspension and axle
Troubleshooting
General inspection
Wheel alignment
Front axle hub
Front suspension
Rear axle hub
Rear drive shaft
Rear differential
Rear suspension
Service specifications
Brake system
General description
Troubleshooting
Check and adjustment
Master cylinder
Brake booster
Front brake 2JZ-GE
Front brake 2JZ-GTE
Rear brake 2JZ-GE
Rear brake 2JZ-GTE
Rear brake (parking brake)
Proportioning and by-pass valve (p & b valve)
Anti-lock brake system (ABS)
Traction control system (TRAC)
Service specifications
Steering
Troubleshooting
On-vehicle inspection
Tilt steering column
Power steering vane pump
Power steering gear
Electronic control system
Service specifications
Supplemental restraint system
General description
Description
Operation
Steering wheel pad and spiral cable
Front passenger airbag assembly
Front airbag sensor
Center airbag sensor assembly
Wire harness and connector
Troubleshooting
Service specifications
Body electrical system
Precaution
Power source
Ignition switch
Headlight and taillight system
Turn signal and hazard warning system
Fog light system
Interior light system
Back-up light system
Stop light system
Wiper and washer system
Combination meter
Seat heater system
Electric tension reducer system
Defogger system
Power window control system
Power seat control system
Power mirror control system
Audio system
Clock
Theft deterrent and door lock control system
Cruise control system
Service specifications
Body
General information
Front bumper
Rear bumper
Hood
Front door
Back door
Wiper and washer
Windshield moulding
Body outside moulding
Windshield
Quarter window glass
Back door moulding and glass
Sport roof
Instrument panel
Front seat
Rear seat
Seat belt
Roof headlining
Service specifications
Air conditioning system
General description
Description
Use of manifold gauge set
Troubleshooting
Refrigerant volume
Drive belt tension
Refrigerant lines
Air conditioning unit
Compressor
Receiver
Condenser
Evaporator
Heater radiator
Water valve
Expansion valve
Blower motor
Blower motor control relay
Servomotor
Pressure switch
Sensor
Electric cooling fan
Relay
Air conditioning amplifier
Air conditioning control assembly
Service specifications
Service specifications
mt1-46
mt1-47
mt1-48
Volksbibliothek
, info@volksbibliothek.com
Back
Toyota Supra JZA80